Webasto SUBARU Legacy Manual do Utilizador descarregar pdf

Subaru Legacy / Out-

back 2.0 D Boxer Diesel

Diesel

from Model Year 2008

Left-hand drive vehicle

Water Heater

Installation instructions

Ident. No.: 1313691D_EN Fee Euro 10.00 © Webasto AG

Feel the drive

WARNING!

Hazard warning:

Incorrect installation or repair of Webasto heating systems may cause a fire or result in the

emission of carbon monoxide, which can be fatal. Serious or fatal injuries can be caused as

a result.

Specialist company training, technical documentation, specialised tools and equipment are

required to install and repair Webasto heating and cooling systems.

Only original Webasto parts must be used. For this, also see the catalog of air and water heat-

er accessories from Webasto.

NEVER attempt to install or repair Webasto heating or cooling systems if you have not

successfully completed the company training and thereby acquired the required tech-

nical skills, or if you do not have access to the required technical documentation, tools

and equipment needed to carry out correct installation and repairs.

ALWAYS follow all Webasto installation and repair instructions and observe all warnings.

Webasto does not accept any liability for defects and damage that are attributable to installa-

tion by untrained staff.

Thermo Top E Parking Heater

00 0003

Thermo Top C Parking Heater

00 0002

1 2 3 4 5 6 ... 24 25

Resumo do Conteúdo

Página 1 - Installation instructions

Subaru Legacy / Out-back 2.0 D Boxer DieselDieselfrom Model Year 2008Left-hand drive vehicleWater HeaterInstallation instructionsIdent. No.: 1313691D_

Página 2 - Table of Contents

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN10Wiring Dia-gram with-out Engine Start/Stop Push But-tonWebasto components Vehicle components Co

Página 3 - Special Tools

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN11Remote option (Telestart)1 Receiver2 Original vehicle bolt3 Bracket, angle down 90°Installing r

Página 4 - Explanatory Notes on Document

1313691D_EN12Subaru Legacy / Outback 2.0 D Boxer DieselPreparing installation locationCut insulation mat 2 at marking.1 Discard section3 Remove clip a

Página 5 - Heater installation location

1313691D_EN13Subaru Legacy / Outback 2.0 D Boxer DieselPreparing heaterReplace 193° cover of circulating pump with axial cover.Replacing pump lid1Ejot

Página 6 - Electrical Connections

1313691D_EN14Subaru Legacy / Outback 2.0 D Boxer Diesel1 Exhaust pipea = 2402 Exhaust end sectionb = 80Discard section XPreparing exhaust pipe1M6x16 b

Página 7 - Fan controller with engine

1313691D_EN15Subaru Legacy / Outback 2.0 D Boxer DieselInstalling heaterInsert 5 mm shim between bracket of heater 2 and body at Position 3.1 M6x20 bo

Página 8

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN16Fuel ConnectionCAUTION!Open the vehicle's fuel tank cap, ventilate the tank and then re-cl

Página 9

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN171 Metering pump2 Fuel line3 Metering pump wiring harnessInstalla-tion loca-tion of metering pum

Página 10

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN18Remove and dismantle fuel-tank sending unit1 according to manufacturer's instruc-tions.2 F

Página 11 - Remote option (Telestart)

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN19Combustion air1 Angle bracket2 Existing stud bolt, original vehicle nutInstalling angle bracket

Página 12

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN2Table of ContentsValidityVehicle and engine types, equipment variants and national specification

Página 13 - Preparing heater

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN20WaterWARNING!Any coolant running off should be collected using an appropriate container. Instal

Página 14

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN21a = 430b = 490Discard section XCutting coolant hoses to lengthCut off hose on engine outlet/hea

Página 15 - Installing heater

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN22Connect-ing heater outletSlide black (sw) rubber isolator 1 onto hose A.Connect-ing heater inle

Página 16 - Fuel Connection

Subaru Legacy / Outback 2.0 D Boxer DieselPrinted in Germany 09/2010 Printing: Steffen231313691D_ENFeel the driveWebasto AGPostfach 80D-82131 Stockdor

Página 17

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN240100 mm100 mmScale 1:1Compare the size of the printed version with dimension lines.Permitted to

Página 18

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN25Operating Instructions for End CustomerPlease remove page and add to the vehicle operating inst

Página 19 - Combustion air

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN3Heater/Installation KitHeater recommended for the relevant vehicle class:The selection of the he

Página 20 - Coolant

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN4Special features are highlighted using the following symbols:The arrow in the vehicle icon indic

Página 21

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN5Preliminary WorkWARNING!- Open fuel tank cap, ventilate tank.- Close the tank cap again.- Discon

Página 22

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN6Electrical ConnectionsPass through of fuel line and wiring harness of metering pump1 Protective

Página 23 - Final Work

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN7Fan controller with engine start/stop push button1 Remove central electrical box, back2 Socket o

Página 24 - Template for Fuel Standpipe

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN8Wiring Dia-gram with Engine Start/Stop Push But-tonWebasto components Vehicle components Colours

Página 25

Subaru Legacy / Outback 2.0 D Boxer Diesel1313691D_EN9Fan controller without engine start/stop push button1 Remove central electrical box, back2 Socke